Product ID:ORONITE SYNFLUID PAO 4 CST, CC67300100
MSDS Date:07/27/1991
FSC:9150
NIIN:00N038177
MSDS Number: BQXFR

CHEVRON

15299 SAN PABLO AVE
RICHMOND, CA 94804
US

Emergency Phone: 415-233-3737

Info Phone: 415-233-3737

Cage: 0AHD1

CHEVRON ENVIRONMENTAL HEALTH CENTER INC

4054 RICHMOND, CA 94804 US

Telephone: 800-582-3835

Cage: 0AHD1

INGEST OF THIS PROD/SUBSEQUENT VOMIT CAN

RTECS: 9999999ZZ

TECHNIQUES SUCH AS SORBENT MATLS/PUMPING. WHERE

RTECS: 9999999ZZ

PRESCRIBED PROCEDURES FOR REPORTING & RESPONDING TO

RTECS: 9999999ZZ

SYNTHETIC HYDROCARBON BASE OIL

CAS: 68649-12-7

Fraction By Weight: 100%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:NOT EXPECTED TO CAUSE
PRLNG/SIGNIFICANT IRRIT. SKIN:NOT EXPECTED TO CAUSE
PRLNG/SIGNIFICANT IRRIT. PRACTICALLY NON-TOX TO INTERNAL ORGANS IF
IT GETS ON SKIN. INHAL:PRACTICALLY NON-TOX TO INTERNAL ORGANS IF
INHALED. INGEST:PRACTICALLY NON-TOX TO INTERNAL ORGANS IF
SWALLOWED. BECAUSE OF LOW VISCOSITY(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OF SUBSTANCE, IT CAN DIRECTLY ENTER
LUNGS IF IT IS SWALLOWED (ASPIRATION). THIS CAN OCCUR DURING
SWALLOWING OR WHEN VOMITING SUBSTANCE. ONCE IN LUNGS, SUBSTANCE IS
VERY DIFFICULT TO REMOVE & CAN CAUSE SEVERE INJURY TO LUNGS &
DEATH.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:EYE:FLUSH W/FRESH WATER FOR AT LST 15 MINS. REMOVE CONTACT
LENSES IF WORN. SKIN:WASH THORO W/SOAP & WATER. REMOVE & WASH
CONTAM CLTHG. INHAL:REMOVE TO FRESH AIR. SUPPORT BRTHG (GIVE
O*2/ARTF RESP) (FP N). INGEST:GIVE WATER/MILK TO DRINK & TELEPHONE
FOR MED ADVICE. DO NOT MAKE PERS VOMIT UNLESS DIRECTED TO DO SO BY
MED PERS. IF MED ADVICE CANNOT BE OBTAINED, THEN TAKE PERS & PROD
CNTNR TO (SUPDAT)

Flash Point Method:COC
Flash Point:425F,218C
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM & WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NORMAL COMBUSTION FORMS CARBON DIOXIDE &
WATER VAPOR; INCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE.

Spill Release Procedures:MATL IS NOT EXPECTED TO PRESENT ANY ENVIRON
PROBS OTHER THAN THOSE ASSOC W/OIL SPILLS. STOP SOURCE OF
LEAK/RELS. CLEAN UP RELS ASAP. CONTAIN LIQ TO PVNT FURTHER CONTAM
OF SOIL, SURF WATER/GROUNDWATER. CLEAN UP SM SPILLS USING APPROP
(ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:READ & OBSERVE ALL PRECAUTIONS ON
PRODUCT LABEL. AVOID PROLONGED OR FREQUENTLY REPEATED SKIN CONTACT
W/THIS MATERIAL.
Other Precautions:CAUTION! DO NOT USE PRESSURE TO EMPTY DRUM/EXPLOSION
MAY RESULT. DO NOT WELD, HEAT/DRILL CONTAINER. REPLACE CAP/BUNG.
EMPTIED CONTAINER STILL CONTAINS HAZARDOUS MATERIAL WHICH MAY
IGNITE W/EXPLOSIVE V IOLENCE IF HEATED SUFFICIENTLY.

Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE
FOR EXPOSURE OF CONCERN . NO SPECIAL RESPIRATORY PROTECTION IS
NORMALLY REQUIRED.
Ventilation:NO SPECIAL VENTILATION IS NECESSARY.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NO SPECIAL SKIN PROTECTION IS USUALLY
NECESSARY. SKIN CONTACT CAN BE MINIMIZED BY WEARING PROTECTIVE
CLOTHING.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NOTE:THESE PRODS ARE USED IN AN/BSY-1(V) COMBAT CNTRL/ACOUSTIC SET,
HIGH FREQUENCY ARRAY UNITS AS FOLLOWS: (A) TR339 TRANSDUCER (2F
5845-01-197-6222 Q1), (B) TR340 TRANSDUCER (2F 5845-01-197-6223
Q1), (C) DT633 HYDROPHONE (2F 5845-01-197-6220-Q1). . FIRST AID
PROC: NEAREST MED EMER TREATMENT CENTER/HOSP. (ING 2)

Spec Gravity:0.82
Solubility in Water:INSOLUBLE
Appearance and Odor:CLEAR, COLORLESS, ODORLESS LIQUID.

Stability Indicator/Materials to Avoid:YES
MAY REACT W/STRONG OXIDIZING AGENTS, SUCH AS CHLORATES, NITRATES,
PEROXIDES, ETC.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:PLACE CONTAMINATED MATERIALS IN DISPOSABLE
CONTAINERS & DISPOSE OF IN A MANNER CONSISTENT W/APPLICABLE
REGULATIONS. CONTACT LOCAL, STATE & FEDERAL ENVIRONMENT OR HEALTH
AUTHORITIES FOR APPROVED DISPOS AL OF THIS MATERIAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.